Importance and Utilization of Maize

Importance and Utilization of Maize

Importance of any crop can be judged by its area, production utilization and share in trade. The same criteria or standards can be applied to maize to judge its importance as cereal crop

1. Area and Production:

Maize is the most widely distributed crops of the world. It is cultivated in tropics, sub-tropics and temperate regions unto 500 and from sea level to 4000 m. Al under irrigated to Semi-arid conditions. Tremendous choice is available as regards to varieties maturing in 85 days to more than 200 days with variability in grain colour and texture etc.

As regards to area and production maize ranks third in world production (380 MT from 120MH) following wheat (440 MT from 240 MH) and rice (420 MT from 140 MH). This represents 24% of the total cereal production as compared to 27 % for wheat and 25% for rice.

More than seventy countries (including 15 developed and 58 developing) produce maize having more than 1, 00,000 ha. Indonesia, Philippines, France, Rumania, Yugoslavia and USSR are the other major maize producing countries. Within India U.P., Bihar, Rajasthan, Madhya Pradesh and Punjab are the maize producing states. Andhra Pradesh ranks 5th with about 3.2 in producing 8.0 Lt of grains.

2. Importance and Utilization

Maize is an important cereal in many developed and developing countries of the world. It is widely used for animal feed and industrial raw material in the developed countries where as the developing countries use it in general for feed. In Indian Agriculture, Maize occupies a prominent position and each part of the maize plant is put to one or the other use and nothing goes as waste. Among the cereal crops in India, maize with annual production of around 10 million tones covering 6 million hectares ranks fifth in area being next to rice, wheat, jower and bajra, fourth n production whereas in productivity it ranks at third position. Maize production in country is fully utilized domestically for food and exports are negligible. Even with the spectacular increase during the recent years in production of the finer cereals i.e., rice, wheat or also of jowar coarse grain, there is no problem of surplus of maize. It is, therefore, inferred that, with the increasing demand for, food grains relative population growth maize will hold its share as an important cereal food grain. Taking into consideration that maize contributes about 6% to the total cereal production and about 23% to the total course grains, the requirement of maize for food will be about 8.25 million tonnes by 2000 A.D.

Conservative estimates on the demands for other uses of maize within the country and for export worked out by the study team on maize constituted by the National Commission by 2000A.D. will be about 7.43 million tones. The details of these are:  Considering the importance of maize in the country for food and industrial uses, the National Commission on agriculture suggested an increase in the supply of this commedity to about 24 million tones. To attain this level of production, it imperative to step up productivity from the existing national average to a level of 2.5 tonnes/ha and also an increase in the area under the crop from 6 to 9 million hectares. Its growth habit and breeding systems have made it an extremely useful plant for scientific qualities etc. have come through maize based research programmes.

Because of its worldwide distribution and relatively lower price maize has wider range of uses.  It is used directly for human consumption, in industrially processing foods, as Live-stock feed and in industrially non food products such as starches, acids and alcohols.  Recently, there has been interest in using maize for production of ethanol a substitute for petroleum based fuels.

As in production and yield, variation exists in utilization pattern between developed and developing countries.

It gives highest average grain yield (30.5 Qt la/ha) as compared to major cereals such as wheat (19.0 qt ls/ha) and rice (25.9 Qt ls/ha). The status maize enjoys as one of the highest yielding among world’s major crops of its own nature viz., efficient utilization of radiant energy and fixations of carbon dioxide from the atmosphere. Also when compared to other crops, the economics of maize cultivation is lowest. Among cereals and millets oil is extracted only from maize.

India occupies fifth place in average under maize in the world, the first four being US, Brazil, China and Mexico Respectively and ranks tenth in production. Maize as a crop has multiple uses but is chiefly grown for human and Livestock consumption. The seeds and the cobs are used as basic raw material in various industries. The seeds are processed and converted into needed preparations, flakes, grits and pops for human consumption.

Nutritionally, maize contains 60 to 68% starch and 7to 15% protein. Opaque seeded types are more nutrition’s and contains a high percentage of essential amino acids. The embryo which forms about 12% of the whole grain is the source of protein, fats and sugars. Yellow maize is the richest sources of Vitamin-A. Maize has more riboflavin than wheat or rice and is rich in phosphorous and potash. Maize contains 1.2 to 5.7 % edible oil. Varieties developed particularly for oil production contain as much as 14%. Maize oil is widely used as a cooking medium and for manufacturing of hydrogenated oil. The oil has the quality of reducing cholesterol in the human blood like sunflower oil. The fat content of the oil is about 80%. Maize acts as a source in the manufacture of starch, syrup, dextrose, oil, gelatin, lactic acid tec. Corn flour is used as a thickening agent in the preparation of many edibles like soups, sauces and custard powder. Corn syrup is used as an agent in confectionary units. Corn sugar (dextrose) is used in pharmaceutical formulations is s sweetening agent in soft drinks etc. corn gel on account of its moisture retention character is used as a bonding agent for ice-cream cones, as a dry Dustin agent for bakingproducts.

Forage and Feed :

The next important field where maize finds extensive use is for livestock feeds viz, cattle Poultry and piggery both in the form of seeds and fodder. The green fodder can be fed to milch cattle to boost the milk production of a considerable extent; “South African Maize” is a best suited variety for fodder. The crop has to be harvested when the grains are in milky stage, This variety is supposed to have Lactogenic effect hence specially suited for milch cattle. The digest ability of maize fodder is higher than sorghum, bajra and other non-leguminous forage crops. Maize plant does not have any problem of  hydrogenic acid or prussic acid production, hence of necessary crop can be harvested and fed to cattle at any stage of its growth, of course ideal stage of harvest for  green fodder mid dough stage, when the dry matter content and digestibility are more desirable. The high carotene content of yellow maize is considered to be very useful in importing yellow colour to egg yok and yellow tinge to the milk. No other concentrate is yet to known to substitute maize in this respect.


In most of the developing countries maize is consumed directly as food. In India, over 85 percent of the maize production is used as food. Most commonly used forms are as (1) Chapattis (2) porridges of various forms (iii) boiled or roasted green ears (iv) breakfast foods like corn flakes and (v) Pop corn. For the (iii) and (v) category sweet and Pop corn varieties are especially grown in USA and Europe.

Other Uses:

The maize cob, the central rachis to which the grains are attached remains as an agricultural waste after threshing; it finds many important agricultural and industrial uses. Approximately it forms 15 to 18% of the total ear weight and contains 35% cellulose, 40% pentose and 15% lignin’s. Their uses in agriculture includes as a litter for poultry and as a soil conditioner.

Industrial Uses:

The industrial uses based on the physical properties of the cob when ground to powder are as fillers for explosives in the manufacture of plastics, glues, adhesives, reyon, resin, vinegar and artificial leather and as diluents and carrier in the formulation of insecticides and pesticides. Based on the chemical properties the processed cobs find their use in the manufacture of furfurol, fermentable sugars, solvents, liquid fuels, charcoal gas and other chemicals by destructive distillation, and also in the manufacture of pulp, paper and hard boards. The water in which in which the maize grains are seaked for the manufacture of glucose is used for growing pencillin moulds.

The economics of cultivation of maize,  jowar and wheat are almost the same: but the cost benefit  ratio in case of maize is highest because of its high productivity. For processing of maize and its products mini factories should b setup around maize growing-areas of our country. This will enhance the demand for maize and its products and the growers can be  directed their produce directly to the factories.

Like all other cereal crops, maize protein, even though possess at reasonably high level is deficient in essential acids like lysine and tryptophan content. In more recent years opaque 2 hybrids and composite varieties developed in several countries have been shown to have twice the lysine and tryptophan content. In India, also three nutritionally superior opaque-2 composite varieties (Shakti, Rattan and Protima) developed in the country were released for commercial cultivation in 1970.

Under poor storage condition, maize grain develop mold which upon eating are extremely harmful to the consumer and may even prove fatal. Unlike local maize varieties, shakti and Ratan was shown to be  resistant to the productions of toxins even if it was infected with the fungus. The opaque strains thus in addition to avoiding the hazards of toxins would also promote better growth and development.

3. Trade:

Among cereal grains maize trade has expended most rapidly increasing from 20 million tonnes in 1961-65 to 60 million tonnes in 1977-79 representing an annual growth rate of 8%. The proportion of world production with trade increased from 10% to 20%. Annual wheat traded was 80 million tones with growth rate being 3.5% and proportion remaining at 16%. The rice trade also increased at about the same rate which was 11 million tones and less than 5% of world production.

Considering only coarse grain grade, maize accounts 70% and Sorghum 11%. The chief exporters of maize are the U.S.A. (74%), Thailand, Argentina, France, South Africa. The importing countries are U.S.S.R., Taiwan, Kores, China, Brazil, Egypt, U.K., Japan and several European countries.

India exported about 18,000 tonnes only.

4. Future Prospects:

The demand for cereals in India will inexprably increase during the next two decants. With the population expected to increase to 985 million by the year 2000, the domestic requirements of food grains at approximately the current levels of consumption have been estimated by the National Commission on Agriculture to be 225 million tonnes in 2000.

Maize, due to its inherently higher yield potential, too National Commission on Agriculture, after a careful consideration o the available date, has observed that  maize will have to contribute more to the meeting of India’s food needs during the next 25 years.

The commission had suggested that maize in the country be increased from 5.7 million hectares to 9.0 million hectares i.e., on increase of 60% of the area by 2000 A.D. and that the yield level be raised to 2.65tonnes/ha to achieve a production of about 24 million hectares. Hence, at the rate of 60% increase in the area, maize has to be cultivated on 0.434 million ha. From this area , the production target envisaged for A.P. by the turn of the 20th Century works out to be 1.5 million tones i.e., 2.65 tonnes/ha. However, going by the experience in the previous decade the targeted area and the production can be exceeded within a decade.

5. Recommended Varieties & Hybrids:

Recommended Varieties & Hybrids:

Rainfed / Irrigated
Duration (Days)
Grain yield / Q/ha Kh/Rb.






Tolerant to foliar diseases
And stalkrots.

DHM 103
105 to 110
Early maturing short duration variety resistant to diseases &stable hybrid

DHM 105
Early maturing short duration variety resistant to diseases &stable hybrid

Tolerant leaf blight & stem borer.

DHM 107
Tolerant leaf blight & stem borer.

DHM 109


Tolerant & stalk borer

A promising composite with uniformicobs

Drought tolerant variety.


Grains for popping low yields are compensated with higher returns

MADHURI (Sweet Corn)
60,000 cobs/ha
Delicious table variety having high sugar (30-36%) in green cobs.